Boxerworks.com

Posted: **Tue May 03, 2016 11:39 pm**

Hey Guys
How's everyone a-doin???
Well, time for a ride again so I'm getting the old gal ready for the Tail Of The Dragon in June. I finally rebuild the master cylinder under the tank that has been leaking for over 20 years and actually replaced the stock brake lines. (like some of you told me to do at one of the rally's at Ken's) Putting on a new tire as well and after removing the back wheel I see the shoes are covered in oil, (kinda explains why the back brakes suck) The rear end is full so wondering where this oil came from????? New shoes on order but can't for the life of me rem how the old ones come off. I did replace the shoes, probably 25 years ago.

Thanks
Kelly VB

Posted: **Wed May 04, 2016 1:06 am**

If you are getting oil transfer from the swingarm to the rear drive, the level can appear full, but still be leaking regardless. Welcome back!

Posted: **Wed May 04, 2016 3:15 am**

Take a look at the final drive with the wheel off and you will see where the oil is leaking from.

Posted: **Wed May 04, 2016 3:24 am**

Is this the issue where the small hole gets blocked?

Posted: **Wed May 04, 2016 8:50 am**

Will be looking at that today as soon as I can remember how to get the brake shoes off

Posted: **Wed May 04, 2016 10:14 am**

It's good to hear from you again.

Posted: **Wed May 04, 2016 10:24 am**

Hey Richard, You too
Man, sure would be good st see everyone again, Is Larry fix-it still around?
Give LaDonna A hug for me!

Kelly

Posted: **Wed May 04, 2016 10:49 am**

KellyVB 75R90S wrote:Will be looking at that today as soon as I can remember how to get the brake shoes off

Nothing could be easier, just lever them off. Use the lever under the shoe that has the cut-out on the thin washer that sort of retains the shoes. Not a big deal, if is levered off with the wrong shoe first, just tap it back flat again.

They go back on the same way.

Posted: **Wed May 04, 2016 2:32 pm**

Was just going to thank you Duane, I looked on your site and found the answer, like you said, (Takes 5 seconds)

Looks like the oil was coming from under the spline, I do remember overfilling at some time in the past and oil was coming out the top breather cap. There was no oil dripping out when I removed the wheel, Just noticed the shoes were oil soaked. I have cleaned everything up and also checked out the 2 weep holes like you show. Guess we will see when the new sketchers are installed...

Boxerworks.com

Ya, I'm Still Here

Ya, I'm Still Here

Re: Ya, I'm Still Here

Re: Ya, I'm Still Here

Re: Ya, I'm Still Here

Re: Ya, I'm Still Here

Re: Ya, I'm Still Here

Re: Ya, I'm Still Here

Re: Ya, I'm Still Here

Re: Ya, I'm Still Here